[DeTomaso] DeTomaso] Unhappy motor - looking for suggestions

Thomas Tornblom thomas at hax.se
Wed Nov 12 16:12:54 EST 2014


You're not running a bronze distributor gear, right?

Cheers,
Thomas


2014-11-12 20:01, Charles McCall skrev:
> Advancing at a snail's pace, but since several people are helping me I wanted to let everyone know what the status is
>
> Just finished wiring up the new MSD box. As Tomas states, I have a totally ginchy wire crimper, so I am confident in the quality of my splices. It's raining so I didn't take the car out for a drive, but it was veeeeery hard to start when cold, which is not normal. It has only been sitting for 8-9 days, and it typically fires at first turn of the key after this time.
>
> Next step will be to assume that my timing is off, maybe a partially sheared shear pin. I'll be out of town again this weekend, so it will be a while before I can check on this, but I'll let people know what I find, for posterity.
>
> As David from Durango says, the guest room is always available, and Spanish wine is really something that must be tried if you aren’t familiar with it. Our rather large wine cabinet is also available for the tech session ;-)
>
> -----Original Message-----
> From: DeTomaso [mailto:detomaso-bounces at poca.com] On Behalf Of R M Services via DeTomaso
> Sent: viernes, 7 de noviembre de 2014 7:10
> To: The Hougans; detomaso at poca com
> Subject: Re: [DeTomaso] DeTomaso] Unhappy motor - looking for suggestions
>
> Hi Charlie
> It is not the distributor cap that would move but the actual rotor arm.
> I would mark the rotor in relation to the body and gently pull the distributor taking care of the oil pump drive. You can then check it properly and eliminate it
>
> Roger
>
> The Hougans wrote:
> While, as others have pointed out, I think you meant accelerator pump, you
> might actually want to check your power valve.  It is internal to the carb,
> but it is not uncommon for them to have 'blown.'  Not sure if that would
> explain all of your symptoms, but the car definitely won't run right.
>
> Mike
>
> -----Original Message-----
> From: DeTomaso [mailto:detomaso-bounces at poca.com]On Behalf Of Charles McCall
> Sent: Thursday, November 06, 2014 10:42 AM
> To: janne at maki-petaja.fi; detomaso at poca.com
> Subject: Re: [DeTomaso] Unhappy motor - looking for suggestions
>
> Hi all
> My power valve injects fuel as it should, so that's one possible cause
> eliminated.
>
> I don't have a timing light - are there any tricks to see if my timing has
> shifted without a timing light?
>
> If my shear pin is starting to fail, would I be able to move the distributor
> cap back and forth, or really only if it has catastrophically failed?
>
> -----Original Message-----
> From: DeTomaso [mailto:detomaso-bounces at poca.com] On Behalf Of Janne
> Mäki-Petäjä
> Sent: martes, 4 de noviembre de 2014 7:29
> To: detomaso at poca.com
> Subject: Re: [DeTomaso] Unhappy motor - looking for suggestions
>
> I'd first suspect the electricals as well. It should start normally with
> the gas in the fuel bowls. Easy to check the primary bowl fuel level though.
>
> Water in the dizzy cap, or plug wire(s) gone bad would be good first
> steps. Plug wire resistance is easily measured with multimeter.
> I've had similar weird MSD problem once, when the distributor wire had
> been laying on the block and worn through the insulator. Grounded the
> dizzy signal occasionally, when it moved around.
>
> -Janne
>
> 3.11.2014 16.09, michael at michaelshortt.com kirjoitti:
>>      Water in the dist cap sounds more likely.
>>
>>      Michael
>>
>>      On Nov 3, 2014 8:48 AM, "Charles McCall" <[1]charlesmccall at gmail.com>
>>      wrote:
>>
>>        A  A Thanks Jeff. It isn't unusually humid here and the car is
>>        always stored
>>        A  A indoors. As I was writing this, however, it occured to me that
>>        it isn't
>>        A  A imposible that some wA!ter may have entered the air cleaner and
>>        dropped
>>        A  A into the carb while washing the car. I'm usually pretty careful
>>        with
>>        A  A where I aim the hose, but I couldn't swear that the engine
>>        stayed dry,
>>        A  A or when opening the decklid when wet, some wA!ter may have run
>>        off near
>>        A  A the cleaner...
>>        A  A A
>>        A  A I will take the air cleaner off and see if I see a healthy
>>        squirt from
>>        A  A the acclerator pump. I don't think it would be fuel pump or
>>        clogged
>>        A  A fuel filter, as it stumbles under trailing throttle as well, it
>>        it can
>>        A  A provide enough fuel for sustainted 115mph running
>>        A  A A
>>        A  A Could it be electrical? My last MSD 6AL gave some really weird
>>        symptoms
>>        A  A that I thought were carb-related before I changed the box and
>>        all my
>>        A  A problems went away. I'll go step-by-step
>>        A  A On Mon, Nov 3, 2014 at 12:55 AM, <[1][2]jgkrenton at comcast.net>
>>        wrote:
>>        A  A Charlie:
>>        A  A How's the weather??
>>        A  A Your problem sort of sounds like it could be water in the fuel
>>        to me.A
>>        A  A Just a drop can be a problem and once you get it in there, it
>>        can hang
>>        A  A around a long time.A
>>        A  A As already mentioned, do the usual things to make sure you
>>        didn't
>>        A  A "introduce" the problem during the recent tuning.AA  Take the
>>        air
>>        A  A cleaner off and see if that makes any difference.AA  Check the
>>        timing
>>        A  A (yes, a pain on the Pantera). Make sure the accelerator pump is
>>        A  A squirting. Check the fuel pressure/fuel pump etc.AA  I have
>>        also been
>>        A  A recently bit by a bad coil and a bad fuel pump.AA  Don't rule
>>        anything
>>        A  A out.
>>        A  A Then dump some "fuel dryer" in the tank and run it a bit to see
>>        if that
>>        A  A helps.AA  Here in Seattle, water in the fuel is a common
>>        problem.
>>        A  A The fuel dryer should help, but there is also the tried and
>>        true "rag
>>        A  A tune".
>>        A  A You have to be careful with this one, but the idea is to rev
>>        the engine
>>        A  A a bit by hand with the air cleaner off.A AA  Then when the
>>        engine is
>>        A  A reving a bit, maybe 2500 RPM, shove a big rag over the carb for
>>        just a
>>        A  A second. (The air-horns, choke, secondary venturies will keep
>>        the rag
>>        A  A from being sucked into the engine). The rag acts like a massive
>>        choke
>>        A  A and the engine will smoke and die if you leave the rag there
>>        for more
>>        A  A than a few seconds.AA  But what this does is raise the full
>>        engine
>>        A  A vacuum up above the throttle plates and jets/ bleeds to the
>>        A  A air-horn/rag level.AA  This "extra" vacuum will draw any water
>>        out of
>>        A  A the jets/bleeds where the "normal" vacuum often is not strong
>>        enough to
>>        A  A pull any water out of the jets.
>>        A  A If your carb is a Holley, you can pull the float chambers off
>>        too and
>>        A  A make sure they don't have water in them....
>>        A  A Good luck.
>>        A  A Jeff/2467
>>        A  A
>>        A __________________________________________________________________
>>        A  A From: "McCall, Charles" <[2][3]charlesmccall at gmail.com>
>>        A  A To: "Mark Charlton" <[3][4]pantera01826 at rogers.com>
>>        A  A Cc: "DeTomaso Mail List" <[4][5]detomaso at poca.com>
>>        A  A Sent: Sunday, November 2, 2014 11:46:48 AM
>>        A  A Subject: Re: [DeTomaso] Unhappy motor - looking for suggestions
>>        A  A Thanks Mark, but I used 3 full tanks of gas in the past 2 days
>>        :-o
>>        A  A The problem has gotten slowly worse, I think.
>>        A  A -----Original Message-----
>>        A  A From: Mark Charlton [mailto:[5][6]pantera01826 at rogers.com]
>>        A  A Sent: domingo, 2 de noviembre de 2014 20:43
>>        A  A To: Charles McCall
>>        A  A Cc: DeTomaso Mail List
>>        A  A Subject: Re: [DeTomaso] Unhappy motor - looking for suggestions
>>        A  A Charlie,
>>        A  A I had a very similar experience with my car during a long tour
>>        in
>>        A  A western
>>        A  A Canada. We checked everything and concluded it must be a carb
>>        issue.
>>        A  A After a
>>        A  A full tear-down of the carb revealed nothing wrong at all, I
>>        filled the
>>        A  A car
>>        A  A (it was 3/4 empty) and the car ran fine again. We concluded
>>        that a
>>        A  A stale
>>        A  A batch of 94 octane gas (not commonly available) caused the
>>        issue. With
>>        A  A any
>>        A  A luck that will be your case too I hope.
>>        A  A Mark Charlton
>>        A  A [6][7]pantera01826 at rogers.com
>>        A  A On Nov 2, 2014, at 2:20 PM, Charles McCall
>>        <[7][8]charlesmccall at gmail.com>
>>        A  A wrote:
>>        A  A > I haven't checked timing, but wouldn't that make the engine
>>        run hot?
>>        A  A >
>>        A  A > Would that explain the stumble? It might explain why it
>>        doesn't feel
>>        A  A as
>>        A  A > crisp as it should
>>        A  A >
>>        A  A > -----Original Message-----
>>        A  A > From: thomas [mailto:[8][9]thomas at hax.se]
>>        A  A > Sent: domingo, 2 de noviembre de 2014 20:18
>>        A  A > To: Charles McCall
>>        A  A > Cc: <[9][10]detomaso at poca.com>
>>        A  A > Subject: Re: [DeTomaso] Unhappy motor - looking for
>>        suggestions
>>        A  A >
>>        A  A > The distributor gear pin?
>>        A  A >
>>        A  A > Checked timing?
>>        A  A >
>>        A  A >
>>        A  A >> 2 nov 2014 kl. 20:13 skrev Charles McCall
>>        A  A <[10][11]charlesmccall at gmail.com>:
>>        A  A >>
>>        A  A >> A Hi all
>>        A  A >>
>>        A  A >>
>>        A  A >> A I just got back from a Supercar event in northern Spain
>>        with 35
>>        A  A cars
>>        A  A >> A attending - Lambo, Ferrari, Viper, Porsche, and, as usual,
>>        a lone
>>        A  A >> A DeTomaso!
>>        A  A >>
>>        A  A >>
>>        A  A >> A The highlight for me without a doubt was an 8-minute burst
>>        on the
>>        A  A >> A highway with the police clearing the way for us, cruising
>>        at a
>>        A  A steady
>>        A  A >> A GPS-indicated 180 k/hr in a 35 car convoy... the people
>>        out for a
>>        A  A >> A Sunday drive must have had their minds boggled...
>>        A  A >>
>>        A  A >>
>>        A  A >> A Anyway, my engine is not happy. This morning in the hotel
>>        parking
>>        A  A lot I
>>        A  A >> A really thought that we'd have to skip today's event
>>        because it
>>        A  A wouldn't
>>        A  A >> A start and didn't sound like it was even thinking about
>>        starting.
>>        A  A Took
>>        A  A >> A probably 5 minutes of crank-wait-crank-wait before it
>>        fired.
>>        A  A Yesterday
>>        A  A >> A at the gas station it took 2-3 minutes to start, something
>>        that
>>        A  A has
>>        A  A >> A never, ever happened before. It is really hard to describe
>>        the
>>        A  A problem
>>        A  A >> A so much of it is "feel", but I'll do my best.
>>        A  A >>
>>        A  A >>
>>        A  A >> A A few weeks ago I noticed that the engine would tend to
>>        stumble if
>>        A  A I
>>        A  A >> A would floor the throttle, then clear its throat and pull.
>>        For
>>        A  A example,
>>        A  A >> A I like to heel-and-toe, just because, and when blipping
>>        the
>>        A  A throttle it
>>        A  A >> A would stumble instead of rev. The engine also felt a
>>        little
>>        A  A rougher, as
>>        A  A >> A though it vibrated more than I remembered it. I don't
>>        remember if
>>        A  A this
>>        A  A >> A was before or after I did a short tune-up, by adjusting
>>        the valve
>>        A  A lash
>>        A  A >> A (I have mechanical lifters), and cleaning the K&N air
>>        filter by
>>        A  A >> A applying K&N filter oil, etc. or if it is irrelevant. So I
>>        was
>>        A  A messing
>>        A  A >> A around in the engine bay recently...
>>        A  A >>
>>        A  A >>
>>        A  A >> A This weekend the engine felt considerably worse. It felt
>>        like it
>>        A  A would
>>        A  A >> A stumble under partial throttle as well. It would stumble a
>>        little
>>        A  A bit
>>        A  A >> A under trailing throttle going downhill as well, so I don't
>>        think
>>        A  A it is
>>        A  A >> A a clogged fuel filter.
>>        A  A >>
>>        A  A >>
>>        A  A >> A Oil temp is perfect. Oil pressure is perfect. Water temp
>>        is
>>        A  A perfect.
>>        A  A >> A The engine idles perfectly. But if you floor the gas from
>>        idle,
>>        A  A it'll
>>        A  A >> A stall. The engine doesn't feel crisp, it feels bloated and
>>        soft,
>>        A  A if
>>        A  A >> A that makes sense. It feels rough, and it feels like it
>>        A  A occasionally
>>        A  A >> A stumbles under constant throttle at highway speed. It
>>        pulls hard
>>        A  A when
>>        A  A >> A accelerating, but I don't think as hard as it used to, or
>>        as high
>>        A  A (I
>>        A  A >> A have a 6500 rpm limiting chip in the MSD that it used to
>>        pull very
>>        A  A >> A easily to).
>>        A  A >>
>>        A  A >>
>>        A  A >> A Suggestions for where to begin looking? And other info
>>        that would
>>        A  A help
>>        A  A >> A in troubleshooting?
>>        A  A >>
>>        A  A >>
>>        A  A >>
>>        A  A >> _______________________________________________
>>        A  A >>
>>        A  A >> Detomaso Forum Managed by POCA
>>        A  A >>
>>        A  A >> DeTomaso mailing list
>>        A  A >> [11][12]DeTomaso at poca.com
>>        A  A >> [12][13]http://poca.com/mailman/listinfo/detomaso_poca.com
>>        A  A >>
>>        A  A >>
>>        A  A >> !DSPAM:54568258260291209923907!
>>        A  A >
>>        A  A >
>>        A  A > _______________________________________________
>>        A  A >
>>        A  A > Detomaso Forum Managed by POCA
>>        A  A >
>>        A  A > DeTomaso mailing list
>>        A  A > [13][14]DeTomaso at poca.com
>>        A  A > [14][15]http://poca.com/mailman/listinfo/detomaso_poca.com
>>        A  A _______________________________________________
>>        A  A Detomaso Forum Managed by POCA
>>        A  A DeTomaso mailing list
>>        A  A [15][16]DeTomaso at poca.com
>>        A  A [16][17]http://poca.com/mailman/listinfo/detomaso_poca.com
>>        References
>>        A  A 1. mailto:[18]jgkrenton at comcast.net
>>        A  A 2. mailto:[19]charlesmccall at gmail.com
>>        A  A 3. mailto:[20]pantera01826 at rogers.com
>>        A  A 4. mailto:[21]detomaso at poca.com
>>        A  A 5. mailto:[22]pantera01826 at rogers.com
>>        A  A 6. mailto:[23]pantera01826 at rogers.com
>>        A  A 7. mailto:[24]charlesmccall at gmail.com
>>        A  A 8. mailto:[25]thomas at hax.se
>>        A  A 9. mailto:[26]detomaso at poca.com
>>        A  10. mailto:[27]charlesmccall at gmail.com
>>        A  11. mailto:[28]DeTomaso at poca.com
>>        A  12. [29]http://poca.com/mailman/listinfo/detomaso_poca.com
>>        A  13. mailto:[30]DeTomaso at poca.com
>>        A  14. [31]http://poca.com/mailman/listinfo/detomaso_poca.com
>>        A  15. mailto:[32]DeTomaso at poca.com
>>        A  16. [33]http://poca.com/mailman/listinfo/detomaso_poca.com
>>        _______________________________________________
>>        Detomaso Forum Managed by POCA
>>        DeTomaso mailing list
>>        [34]DeTomaso at poca.com
>>        [35]http://poca.com/mailman/listinfo/detomaso_poca.com
>>
>> References
>>
>>      1. mailto:charlesmccall at gmail.com
>>      2. mailto:jgkrenton at comcast.net
>>      3. mailto:charlesmccall at gmail.com
>>      4. mailto:pantera01826 at rogers.com
>>      5. mailto:detomaso at poca.com
>>      6. mailto:pantera01826 at rogers.com
>>      7. mailto:pantera01826 at rogers.com
>>      8. mailto:charlesmccall at gmail.com
>>      9. mailto:thomas at hax.se
>>     10. mailto:detomaso at poca.com
>>     11. mailto:charlesmccall at gmail.com
>>     12. mailto:DeTomaso at poca.com
>>     13. http://poca.com/mailman/listinfo/detomaso_poca.com
>>     14. mailto:DeTomaso at poca.com
>>     15. http://poca.com/mailman/listinfo/detomaso_poca.com
>>     16. mailto:DeTomaso at poca.com
>>     17. http://poca.com/mailman/listinfo/detomaso_poca.com
>>     18. mailto:jgkrenton at comcast.net
>>     19. mailto:charlesmccall at gmail.com
>>     20. mailto:pantera01826 at rogers.com
>>     21. mailto:detomaso at poca.com
>>     22. mailto:pantera01826 at rogers.com
>>     23. mailto:pantera01826 at rogers.com
>>     24. mailto:charlesmccall at gmail.com
>>     25. mailto:thomas at hax.se
>>     26. mailto:detomaso at poca.com
>>     27. mailto:charlesmccall at gmail.com
>>     28. mailto:DeTomaso at poca.com
>>     29. http://poca.com/mailman/listinfo/detomaso_poca.com
>>     30. mailto:DeTomaso at poca.com
>>     31. http://poca.com/mailman/listinfo/detomaso_poca.com
>>     32. mailto:DeTomaso at poca.com
>>     33. http://poca.com/mailman/listinfo/detomaso_poca.com
>>     34. mailto:DeTomaso at poca.com
>>     35. http://poca.com/mailman/listinfo/detomaso_poca.com
>>
>>
>>
>> _______________________________________________
>>
>> Detomaso Forum Managed by POCA
>>
>> DeTomaso mailing list
>> DeTomaso at poca.com
>> http://poca.com/mailman/listinfo/detomaso_poca.com
>
>
>
> _______________________________________________
>
> Detomaso Forum Managed by POCA
>
> DeTomaso mailing list
> DeTomaso at poca.com
> http://poca.com/mailman/listinfo/detomaso_poca.com
>
>
> _______________________________________________
>
> Detomaso Forum Managed by POCA
>
> DeTomaso mailing list
> DeTomaso at poca.com
> http://poca.com/mailman/listinfo/detomaso_poca.com
> _______________________________________________
>
> Detomaso Forum Managed by POCA
>
> DeTomaso mailing list
> DeTomaso at poca.com
> http://poca.com/mailman/listinfo/detomaso_poca.com
>
>
> _______________________________________________
>
> Detomaso Forum Managed by POCA
>
> DeTomaso mailing list
> DeTomaso at poca.com
> http://poca.com/mailman/listinfo/detomaso_poca.com
>
>
> !DSPAM:5463aea31842085765980!
>


-- 
Real life:   Thomas Törnblom             Email:	   thomas at hax.se
Snail mail:  Banvallsvägen 14            Phone:    +46 18 32 31 18
              S - 754 40 Uppsala, Sweden  Mobile:   +46 76 209 8320





More information about the DeTomaso mailing list