[DeTomaso] Clutch Chatter

[Forest Goodhart]

Garth,
I assume you are referring to the pilot bushing and not the throwout hub.
Forest




________________________________
From: Garth Rodericks <garth_rodericks at yahoo.com>
To: Mike Thomas <mbefthomas at comcast.net>; DeTomaso Mail List 
<detomaso at realbig.com>
Sent: Mon, October 3, 2011 11:29:48 AM
Subject: [DeTomaso] Clutch Chatter

Mike,

Did you replace your throwout bushing?  An old or improperly sized throwout 
bushing will create these symptoms. And if you're using a throwout 'bearing' 
instead of a proper bronze bushing, it will likely be history after getting 
hammered to death by the chattering. Something to check when you pull the ZF.

Good luck!
Garth
#4033


--- Original Message ---
I've got a fairly new McLeod dual plane clutch purchased this summer from
Dennis that has begun to chatter when rolling out in first or in reverse.
I've got about 700 miles on the clutch at this point, so it's gone through
it's break-in.  The clutch I removed was a Centerforce, albeit the wrong
one, and had been in the car for about 10,000 miles before I pulled the ZF
to have it rebuilt.  I did not have the flywheel resurfaced as I had done so
when the new motor went in back in 2007, and to Dennis' instructions, gave
it a light going over with fine-grit red garnet sand paper on a flat sanding
block.  Both the new pressure plate and flywheel were then thoroughly
cleaned with brake cleaner. Is there anything I can do to minimize/cure the 
chatter short of pulling the
ZF and resurfacing the pressure plate and flywheel?
Is this something that is going to get worse over time? I sure miss the 
counter-weighted diaphragm design of the Centerforce.  The
3-finger McLeod starts to take a toll on my running-abused ankle after a
long day of driving. Thanks in advance Mike Thomas
Panteras Northwest
_______________________________________________

Detomaso Forum Managed by POCA

Archive Search Engine Now Available at http://www.realbig.com/detomaso/

DeTomaso mailing list
DeTomaso at list.realbig.com
http://list.realbig.com/mailman/listinfo/detomaso